2 ton oil steam boiler

Combustion gas treatment unit and a fault, gas boiler burner ignition misfire rod reasons: 1, the ignition bar gap interposed carbon residue with oil. 2, ignition rods fragmentation. moist. Leakage. 3, the distance between the ignition does not stick, too long or short. 4, ignition rods Insulation damage, short to ground. 5, ignition cable and transformer failure: cable, connector damage caused by a short circuit during ignition; transformer break or other fault occurs. Measures following five: Clear, renewal, adjust the distance, change and switching transformer. Second, gas boiler, but spark ignition rods misfire reasons: 1, the cyclone disc space ventilation is blocked carbon, poor ventilation. 2, dirty oil nozzle clogging or wear. 3, the throttle angle is set too small. 4, the firing bar from the leading edge from the oil nozzle tip inappropriate (too protruding or retracted) 5, the first solenoid valve is an oil debris blocking gun (gun small kerosene). 6, oily or too viscous to flow easily clogged or the oil filtration system the valve is not opened, so that insufficient suction pump, oil pressure. 7, the filter pump itself blocked. 8, the oil more water (boiling abnormal noise within the heater). Measures are: Clear; first wash, such as not renewed; turndown test; adjusting the distance (in 3 ~ 4mm as well); Remove cleaning (cleaning the parts diesel); Check tubing and oil filters, insulation equipment ; remove peripheral screw pump, carefully remove the cover inside out oil network, with immersion oil; renewal of the test oil. Third, when the gas boiler and turn the fire a small fire normal, off, or flashing instability reasons: 1, the air volume damper setting fire too. 2, oil fires micro switch valve (damper outermost that group) inappropriate setting (set throttle air flow rate is greater than the fire). 3, oleaginous easy to spray viscosity is too high (heavy). 4, and the nozzle plate spacing cyclone inappropriate. 5, fire nozzle worn or dirty. 6, the preliminary fuel tank temperature is too high, so that the steam not smooth oil pump oil feed. 7, fuel oil boiler water. Action: Test gradually reduced; heating temperature; adjusting the distance (between 0 ~ 10mm); clean or replace; approximately set to about 50 deg.] C; or drain oil change. Fourth, the noise increases gas boiler burner reasons: 1, cut-off valve is closed or the passage into the fuel shortage, an oil filter blockage. 2, the oil inlet temperature is low, the oil viscosity is too high or the temperature is too high the pump inlet. 3, oil pump failure. 4, fan motor bearing damage. 5, dirty fan impeller. Processing methods: ① the oil line check valve is open, if the oil filter is working properly, the filter cleaning pump itself. ② heating oil or reduce the oil temperature. ③ Replace the oil pump. ④ replace motor or bearings. ⑤ cleaning fan wheel.

There are several series of oil and gas 2 ton steam boilers produced by ZG boiler, wns oil and gas steam boilers and szs steam boilers. These two series of boilers mainly use natural gas, petroleum and heavy oil as fuel. The boilers are medium and small capacity boilers, and there is no noise and no ash. The boiler has high automation and convenient operation. The oil and gas boiler is a kind of boiler suitable for the textile industry. A textile factory in Bangladesh has cooperated with Z ZG boiler to purchase two wns oil and gas steam boilers.

Combustion gas treatment and a malfunction due to gas boiler burner ignition misfire bar: 1, the ignition bar gap interposed carbon residue with oil. 2, ignition rods fragmentation. moist. Leakage. 3, the distance between the ignition does not stick, too long or short. 4, ignition rods Insulation damage, short to ground. 5, ignition cable and transformer failure: cable, connector damage caused by a short circuit during ignition; transformer break or other fault occurs. Gas Burner fails, the action bar ignition misfire following five: Clear, renewal, adjust the distance, change and switching transformer. Second, the gas boiler the ignition spark rod misfiring but the reasons: 1, the disk space ventilation carbon cyclone is blocked, poor ventilation. 2, dirty oil nozzle clogging or wear. 3, the throttle angle is set too small. 4, the firing bar from the leading edge from the oil nozzle tip inappropriate (too protruding or retracted) 5, the first solenoid valve is an oil debris blocking gun (gun small kerosene). 6, oily or too viscous to flow easily clogged or the oil filtration system the valve is not opened, so that insufficient suction pump, oil pressure. 7, the filter pump itself blocked. 8, the oil more water (boiling abnormal noise within the heater). Gas boiler ignition spark rod action but misfiring are: clear; the first washing, such as not renewed; turndown test; adjusting the distance (in 3 ~ 4mm as well); Remove cleaning (cleaning the parts diesel) ; check the pipeline and oil filters, insulation equipment; peripheral screw pump removed, carefully remove the cover inside out net oil, diesel oil immersion; renewal of the test oil. Third, when the gas boiler and turn the fire a small fire normal, off, or flashing the causes of instability: 1, air volume damper setting fire too. 2, oil fires micro switch valve (damper outermost that group) inappropriate setting (set throttle air flow rate is greater than the fire). 3, oleaginous easy to spray viscosity is too high (heavy). 4, and the nozzle plate spacing cyclone inappropriate. 5, fire nozzle worn or dirty. 6, the preliminary fuel tank temperature is too high, so that the steam not smooth oil pump oil feed. 7, gas hot water boiler fuel oil water. When a small fire gas boiler normal and turn the fire extinguished or flashing instability action: Test gradually reduced; heating temperature; adjusting the distance (between 0 ~ 10mm); clean or replace; i.e., set to about 50 deg.] C may be; or drain oil change. Fourth, the noise increases gas boiler burner reasons: 1, cut-off valve is closed or the passage into the fuel shortage, an oil filter blockage. 2, the oil inlet temperature is low, the oil viscosity is too high or the temperature is too high the pump inlet. 3, oil pump failure. 4, fan motor bearing damage. 5, dirty fan impeller. Burner gas treatment increased noise: ① the check valve in the oil line is open, if the oil filter is working properly, the filter cleaning pump itself. ② heating oil or reduce the oil temperature. ③ Replace the oil pump. ④ replace motor or bearings. ⑤ cleaning fan wheel.

Boiler plant equipment as three major important energy conversion device, fuel chemical energy into heat energy, and the pot was heated using thermal energy to become hot water having a sufficient quantity and a mass (steam temperature, steam pressure) steam turbine for use. The Anyang City, the power company to my company to buy a split 2 tons of steam condensing gas 2 ton steam boiler for supplying electricity demand. The WNS series split condensing boilers using advanced technology designed to greatly improve the thermal efficiency of the boiler, up to about 96%.

2 ton oil steam boiler Related Information

1 ton steam boiler

2019-3-20 · 1 t/h Steam boiler is basically a closed vessel into which water is heated and converted into steam at required pressure. In the steam generator boiler, the feed water and steam are in the principle passing through one long tube - designed as winded-up tube coils that are serially connected. 1 ton per hour steam boiler is a small steam boiler, and widely used in construction equipment industry

Get A Quote

Oil fired 2 ton steam boiler price - WNS2-1.25-Q -

2017-11-27 · Oil fired 2 ton steam boiler price WNS2-1.25-Q - Yuanda Boiler Products Made In China, China Manufacturer. WNS2-1.25-Y 2 ton oil fired steam boiler 2 ton oil fired boiler Yuanda Boiler General description: 1. Boiler Model: DZL and SZL for coal or biomass fired boiler sale; WNS for gas or oil fired boiler sale; LHS and LSC for vertical boiler sale; DZH and SZH for manual fixed grate boiler sale 2.

Get A Quote

2 ton oil steam boiler - hs-schauer.de

2 ton steam boiler. 2018-6-28 · Steam boiler is a horizontal three-pass shell type dual wet back boiler. The 2 ton steam boiler has an automatic control systems, energy saver and other auxiliary equipment and valves instrumentation. 2ton per hour steam boilers from manufacturer ZG : Natural Efficiency Up to 85% efficiency Radiant heat is maximized across the primary heating surface Flues

Get A Quote

2 Ton/hr Gas Steam Boiler Project in Coating Factory,2

2020-5-12 · Paint production requires steam, and 2 ton gas fired boiler can supply good quality steam to meet a coating factorys need. The WNS series gas fired boiler manufactured by ZG Group is an ideal high efficiency and energy saving boiler to replace coal fired boiler.

Get A Quote

500kg 1 ton 2 ton 3 ton 10 ton steam boiler

3 pass fire tube steam boiler Gas oil fired 500kg 1 ton 2 ton 3 ton 10 ton steam boiler

Get A Quote

MAIKE BOILER

MAIKE BOILER is the professional manufacturer of quality boiler and pressure vessel in China, specializing in development, production and trade. Our factory was established in 1965 and has more than 50 years history. Russia 8 ton oil& gas fired steam boiler. Kazakhstan 20ton Biomass Kazakhstan 20ton Biomass Boiler +86 15981894106. Hot

Get A Quote

Oil Steam Boiler on sales of page 4 - Quality Oil Steam

Oil Steam Boiler, You can Buy good quality Oil Steam Boiler of page 4, we are Oil Steam Boiler distributor & Oil Steam Boiler manufacturer from China market. 12 Ton 16 Bar Heavy Oil Fired Steam Boiler Low Pressure Running Efficiently Boiler Description 1. This boiler is horizontal type, fire tube, three pass shell boiler.

Get A Quote

China 2 Ton Dual Fuel Steam Boiler Supplier and

2020-4-13 · 2 Ton Dual Fuel Steam Boiler Manufacturers, Factory, Suppliers From China, And there are also many foreign friends who came for sight seeing, or entrust us to buy other stuff for them. You are most welcome to come to China, to our city and to our factory!

Get A Quote

Nigeria 2 ton integrated condensing oil steam boiler

2019-11-25 · Product advantages. This series of steam boilers greatly enhances heat transfer efficiency by using a non-cutting extruded finned tube. The integrated condensing design combines an economizer with a condenser to significantly increase boiler thermal efficiency.

Get A Quote

2 ton mobile gas or oil fired steam boiler

2 ton mobile gas or oil fired steam boiler. DHL Series Biomass-fired Industrial Steam Boiler. DHL series biomass-fired industrial steam boiler is field assembled boiler, it uses a piping system as the frame of the entire boiler. Learn More Get a Quote;

Get A Quote

2 ton gas and oil fired steam boilers price bhiwandi

2 ton steam boiler. 2018-6-28 · The 2 ton steam boiler has an automatic control systems, energy saver and other auxiliary equipment and valves instrumentation. 2ton per hour steam boilers from manufacturer Industrial Steam Boiler For Sale : Natural Efficiency Up to 85% efficiency Radiant heat is maximized across the primary heating surface

Get A Quote

2 Ton/hr Gas Steam Boiler Project in Coating Factory,2

2020-5-12 · Paint production requires steam, and 2 ton gas fired boiler can supply good quality steam to meet a coating factorys need. The WNS series gas fired boiler manufactured by ZG Group is an ideal high efficiency and energy saving boiler to replace coal fired boiler.

Get A Quote

2 Ton Heavy Oil Fired Boiler

2020-5-8 · Boiler Project: Food Processing Plant Project in Senegal Boiler Specification: WNS 2tph heavy oil fired steam boiler, full-automatic operation, several safety device ensure 100%, long using life up to 30 Years. Boiler Recommend: Yuanda boiler has sold 5000+ sets boiler used for food production industry, mostly, customers choose WNS series steam/hot water boiler, available fuel: gas,diesel

Get A Quote

2 ton mobile gas or oil steam boiler for sale ZOZEN

2 Ton Steam Boiler Alibaba. 2 ton wns oil/gas fired steam boiler for textile industry. US $5000-$100000 / Set 1 2 4 Ton DZG Fixed Grate Coal Fired Steam Boiler for Sale. Ask Price View More; Steam Boiler Price Alibaba.com. About 69% of these are Boilers, 2% are Boiler Parts.

Get A Quote

Full Automatic 1.5 Ton Gas Oil Biogas Fired Steam

Full Automatic 1.5 Ton Gas Oil Biogas Fired Steam Boiler, Find Complete Details about Full Automatic 1.5 Ton Gas Oil Biogas Fired Steam Boiler,Biogas Fired Steam Boiler,1.5 Ton Oil Boiler,Automatic Gas Boiler from Boilers Supplier or Manufacturer-Henan Province Sitong Boiler Co., Ltd.

Get A Quote

DO YOU HAVE QUESTIONS? WE ARE HERE TO HELP YOU!