SZS high efficiency oil fired water tube boiler

After installation and commissioning fast Boiler professional and technical personnel, two hot water szs high efficiency fired water tube boilers to provide our bodies quickly into the orbit of the normal operation. Meanwhile, the design of energy-saving equipment also effectively improve the thermal efficiency of the boiler, saved us a huge amount of fuel costs. --customer feedback

Pressure fire operations and precautions Henan fast szs high efficiency fired water tube boiler's steam boiler Xiao Bian told you about the operation of steam boilers and pressure fire precautions and stainless steel high temperature magnetic pump structural characteristics 1. pressure steam boiler fire steps of (1) to reduce boiler load, according to the length of time of shutdown, the seam thicker, the thickness is generally not more than 200 mm, suitable to accelerate the speed of the grate. (2) to the slag is thickened seam about 1 mm from the stop grate rotation, the drum is stopped, the operation of the induced draft fan, blowing off a small segment of the regulating plate stopper and dampers qs, relying on natural ventilation to maintain coal the lean-burn, the sewage, boiler water level will rise to the maximum allowable level. If the fire burn coal gate, grate can be switched on again, the coal-fired back, a distance. (3) the recovery boiler needs to run, as long as the opening lead, a blower, to adjust the smoke, and the wind baffle plenum segment adjusting the opening degree of the shutter, the adjustment of combustion steam boiler seam thickness to be normal, start grate, can be restored run. 2. Note the use of a steam boiler (1) before starting Check power supply voltage, there are unusual circumstances water, close the drain valve opens the water supply valve, check whether the pump stuck, stuck if the pump, remove the fan cover, rotation of the motor shaft to the flexible state to boot. (2) When the steam boiler maintenance or replacement of parts, turn off the power to avoid live work dangerous. (3) electronic control box, pump motors and other parts should avoid damp water to prevent burning boiler should pay attention to keep clean. (4) steam boilers in accordance with quality requirements, when using the apparatus sure to install a water softener, the water softener is not used because the boiler may cause fouling, may cause serious squib, shortening the life of the boiler. (5) Please note that when using sewage. And at least once a day with a discharge pressure of between 0.1MPa to 0.15MPa discharge may be prevented clogging of pipes, sewage should be properly connected, to guard against burns. Stainless steel high temperature magnetic pump structural features: a sliding bearing magnetic pump sliding bearing materials impregnated graphite, PTFE and engineering ceramics. Because of engineering ceramics has good heat resistance, corrosion resistance, abrasion performance, so the sliding bearing magnetic pump more use of engineering ceramics production. Because of engineering ceramics are brittle and expansion coefficient, so the bearing clearance is not too small, so as not to hold the shaft accident. Since the magnetic pump in order to lubricate sliding bearing medium conveyed, it should be used depending on the medium and conditions, making use of different materials bearing. 2. Cooling lubricating fluid flow control pump operation must be flush cooling internal friction annulus region between the sliding bearing and the magnetic rotor and the containment shell with a small amount of liquid. Coolant flow rate is typically 2-3% of the design flow of the pump, the annulus area between the inner magnetic rotor of the eddy current generated spacer bush high heat. When enough cooling lubricant or flushing holes poor, clogging, the medium will result in a temperature above the operating temperature of the permanent magnet, the inner magnetic rotor gradually loses its magnetism, the magnetic force actuator failure. When the medium is water or water-based liquid, the temperature rise can be maintained in the annulus region of 3-5 deg.] C; or when the medium is a hydrocarbon oil, allows the annulus region of the temperature was maintained at 5-8 ℃. Henan is committed to fast boiler steam boiler manufacturing, product quality, reasonable prices and widespread industry praise, if you have any needs, please contact us!

Boiler fire phenomenon, how to do 1, furnace pressure fluctuations or to limit and alarm. 2, no flame detector flame, flame flameless television display. 3, flue gas oxygen abnormal fluctuations. 4, steam pressure steam temperature dropped drastically. 5, furnace black, black smoke chimney. 6, the flue gas temperature is reduced. 7, MFT action, turbine trip, splitting the unit. Cause 1, the furnace combustion conditions organizations unreasonable, improper wind coal proportion. 2, the load is too low, unstable combustion conditions without oil combustion vote, or vote, although oil but not good combustion results. 3, cast oil, poor quality oil, oil spray gun is bad, low oil pressure, oil system failure. 4, poor coal quality, coal is too rough, the water is too large pulverized coal combustion adjustment is not timely. 5, the primary air temperature, air pressure is too low. 6, szs high efficiency fired water tube boiler MFT protection action. 7, a large area of ​​the furnace coke collapse, smashing off the flame. 8, severe water wall pipe explosion will blow out the flame. 9, all coal-fired condition, mill pulverizing system failure caused most or all trips. 10, a part of auxiliary machinery such as a fan, blower, fan, air preheater tripped, causing unstable furnace combustion conditions. 11, sootblowing properly, resulting in a large number of normal operation of the furnace ash effects of fire inspection of the boiler. 12, bottom seal damage. Treatment 1, the boiler fire, MFT should be action, otherwise manual MFT. 2, normal inspection device linkage linkage MFT, confirm that all fuel cut. 3. quickly identify the cause, try to eliminate the boiler can be re-ignition, the recovery unit operation. 4, when the mill started again after the trip, the trip must be the primary air tube mill full purge. 5, the MFT operation, checks, Fan normal operation, automatic furnace vent. 6, the MFT movement, check all the secondary purge air damper position is set, the total air volume is automatically adjusted to 30 ~ 40% BMCR sufficiently purged air volume. 7, the MFT operation, when the turbine is in a state disk drive, the disk drive must continue until the normal turbine eccentricity, before re turn red. 8, if temporarily unable to identify or eliminate the cause, restart and could threaten personal safety equipment, non-start. 9, processing according to the corresponding predetermined remaining MFT.

Boiler multiple protection: (1) the integration of szs high efficiency fired water tube boiler water level to protect water level and boiler design, the appearance of more compact appearance, accurately show the actual water level in the boiler body function. Coupled with dual independent electronic water level control system to achieve ultra-low water level in the boiler, low water level automatic adjustment function, the normal water level, high water level, ensure that the boiler in a variety of unforeseen circumstances foolproof, secure home. (2) steam pressure protection ☆ pressure controller: selection of high sensitivity of the pressure controller, the pressure is high, or low levels of signal to the electrical switch, other control lines or automatic control chain protection. Common pressure controller and pressure gauge, vapor pressure overpressure alarm can cut off the burner limit is reached; the pressure controller may be single or double fire burning fire the actual operating pressure regulator. ☆ safety valve: safety valve is the last line of defense to protect the boiler, the boiler pressure exceeds the limit, according to the set pressure relief valve design with the school, the exhaust steam pressure relief, to ensure the normal operation of the boiler. (3) having a burner flame protection flame protection inlet means, combustion function is to detect, when the ignition failure or extinguish combustion middle, immediately off the burner into the oil (gas) solenoid valve, the blower continues to operate at this time, the furnace was purged combustible residual gas, after 20 to 30 seconds purge, and various auxiliary blowers automatically cut off power, the boiler operation stops. (4) self-locking power failure protection case, the boiler shutdown immediately burst self-locking power interruption, if the current power is restored, the boiler will not start at any time, you must reset release self-locking, to re-start the ignition.

SZS high efficiency oil fired water tube boiler Related Information

China Szs Oil/Gas Fired Steam/Hot-Water Boiler -

China Szs Oil/Gas Fired Steam/Hot-Water Boiler, Find details about China Boiler, Steam Boiler from Szs Oil/Gas Fired Steam/Hot-Water Boiler - QINGDAO HAMMER INDUSTRIES CO., LTD.

Get A Quote

water tube boiler,biomass boiler, gas boiler,oil boiler

2019-11-28 · Capacity: 4 - 90Ton; Fuel: Blast furnace gas, coke oven gas, natural gas, oil; The SZS series boiler is a D-Type packaged water tube boiler, with lots of advantages: high combustion efficiency, low emission, convenient operation, easy installation, high automatic degree, which can be an ideal energy saving, high efficiency, environment friendly boiler equipment in the application field of

Get A Quote

Oil and gas water tube boiler -- Boiler

2019-8-15 · The oil and gas water tube boiler is a szs series industrial boiler. The boiler adopts a double drum vertical arrangement. The boiler adopts a quick assembly structure, has the characteristics of compact structure and short installation period on the construction site.

Get A Quote

SZS series gas-fired(oil-fired) hot water boiler

2019-5-21 · SZS series gas-fired(oil-fired) hot water boiler introduction. SZS series boiler is designed with longitudinal double drums and " D " type chamber structure. The furnace is on the right and convection tube bank is on the left. The body is fixed on the basement by middle and both end flexible supports and make the boiler expand horizontally

Get A Quote

szs series water tube boiler - hs-schauer.de

2019-8-15 · The Zozen oil and gas water tube boiler is a szs series industrial boiler. The boiler adopts a double drum vertical arrangement. The boiler adopts a quick assembly structure, has the characteristics of compact structure and short installation period on the construction site. Read More; SZS Series oil gas Fired Water Tube Steam Boiler

Get A Quote

SZS Gas & Oil Fired Boiler-Taiguo Boiler

SZS series oil gas fired water tube boiler adopts double drums "D-type" vertical arrangement, full-membrane wall structure, reasonable and compact layout, realize large-capacity boiler overall quick installation, less investment in boiler house infrasturcture and short installation period.

Get A Quote

industrial boiler manufacturer,steam boiler company

2020-3-27 · WNS Series Oil Gas Fire Tube Steam Boiler-----WNS Series steam boiler is a kind of high thermal efficiency (98%) boiler with the full automatic control system. It is three-return packaged fired tube steam boiler with wet back structure. Compared w

Get A Quote

High Efficiency industrial coal fired steam boiler Supplier

High Efficiency industrial coal fired steam boiler Supplier,coal fired water tube boiler,coal fired boiler manufacturers,coal fired water tube boiler.

Get A Quote

gas fired steam boiler, oil fired steam boiler, SZS oil

2019-9-11 · Overview. Brief Introduction: SZS series oil and gas fired boiler is a packaged water tube boiler with double drums and D-type layout. It has lots of advantages such as sufficient burning, no pollution in the emission, convenient operation, easy installation etc.

Get A Quote

SZS Double Drums Water Tube Boiler Posteezy

2020-5-16 · Oil & Gas Fired Boiler, Vertical Boiler, Double Drums Water Tube Boiler, Vertical Boiler For Sale Factory. Advantages 1. Manhole, inspection door Manholes are set at the front and back of the furnace as well as the above and bottom part, the inspection door is set at the hind part of the boiler, easy to open from check and cleaning. 2.

Get A Quote

High Efficiency High efficiency Water Tube Steam

Vertical Steam Boiler. Devotion LSS Vertical Steam Boilers are available under 2 ton per hour. Rated steam output ranges 0.3, 0.5, 0.75, 1.0, 1.5, 2 tons per hour Applicable with fuel of light oil, heavy oil, natural gas and LPG Features: small footprint, easy to install, small water volume and quick start-up

Get A Quote

Water Tube Oil / Gas Fuel Boiler - Bosch

A highly-efficient stand alone economizer is installed at the rear end of the boiler to lower the flue gas temperature and improve the boiler thermal efficiency. You can find further information in our SZS Oil and Gas Fired Water Tube Packaged Boiler brochure.

Get A Quote

steam boiler with condenser, high efficiency boiler

2020-5-20 · Main accessories of Gas/Oil fired boiler: Boiler Advantages: 1. High efficiency rating of up to 99% with integrated economizer. 2. Versatile design for using different fuel and multi-fuel fired unit. 3. Satisfy local environment emission level standard strictly. 4. PLC Intelligent Control system, work full-automatically and safety. 5.

Get A Quote

Surprise Price Szs Series Gas/oil Fired Steam Boiler -

Features of Surprise price szs series gas/oil fired steam boiler. 1. This kind of boiler adopts the structure of double longitudinal drums and D-type furnace. Water tube design, The economizer and other auxiliary heating surface are fixed in the rear. The combustor is located on the front wall.

Get A Quote

SZS Series Gas and Oil Fired Water Tube Packaged Boiler

2016-3-9 · Gas and Oil Fired Water Tube Packaged Boiler Bosch is a renowned specialist worldwide for standard and customised boiler systems of all sizes and performance categories. For over 140 years Bosch has been providing innovative, energy-efficient, eco-friendly and high quality boiler solutions for commercial and industrial applications.

Get A Quote

DO YOU HAVE QUESTIONS? WE ARE HERE TO HELP YOU!