High performance gas fired 2 ton steam boiler

What are the precautions in the loading and installation of gas-fired high performance fired 2 ton steam boilers?

Gas-fired steam boilers are a very wide range of special equipments, widely used in food, chemical, paper, textile, construction and other industries. In the process of loading and installing a gas steam boiler, some problems must be paid attention, otherwise it may cause a certain degree of economic loss.

1. Pay attention to the following matters during the loading and unloading and handling of gas-fired boilers: the lifting capacity of the lifting equipment should match the weight of the lifting boiler. The lifting lug on the boiler with the lifting lugs that cannot be used for lifting can not be used for lifting. The length of the steel cord should be reasonably selected to avoid the scratching of the furnace due to the improper length of the steel cord. The boiler must be protected from any damage during handling and handling.

2. Reserves for maintenance space When installing boilers, ensure that there is sufficient maintenance space around the boiler.

3. Setting and precautions for the base and base of the gas steam boiler The boiler body must be installed on the basis of 100-150mm above the floor of the boiler room. It must be confirmed with the technical personnel of the boiler manufacturing company in advance and constructed according to the basic drawings. The anchor bolts must be reserved on the foundation. The foundation shall be capable of withstanding the maximum weight of the boiler and the amount of water it holds. When installing the base, you must first position it. After positioning, adjust to the same length of the two diagonals of the base, and then tighten all the fixing bolts. The installation of the base is carried out with reference to the reference line.

4, general precautions Be careful not to tilt and impact the boiler and accessories too much. No combustibles can be placed around the boiler. Do not use oil and water to smother the boiler. The boiler should normally be installed in a separate boiler room. The new gas-fired boiler room should not be connected to the house. The boiler room shall not be connected to Class A, Class B and Category C fire hazard rooms using flammable liquids. If connected to other production plants, the application firewall is separated.

5. The fire resistance grade and fire protection requirements of the boiler house building shall comply with the requirements of the Code for Fire Protection of Building Design and the Code for Fire Protection Design of High-rise Civil Buildings. The ground of the gas steam boiler room should be flat, non-flammable, no water accumulation, and the foundation load should meet the requirements. The power supply voltage of the gas steam boiler room should be stable to avoid causing the electrical components to burn out. If the voltage is unstable, it is recommended to install a voltage regulator. Ventilation equipment should be installed in the boiler room, and the boiler should be kept at room temperature below 50 °.

If you know a little about chemistry, you may know that the sulfur content of oil and coal is roughly equal, but ask what low-temperature corrosion of oil-fired boilers is much more serious than coal-fired boilers, for two main reasons:

1. 90% of ash in coal-fired boiler, especially coal powder furnace, is taken away by flue gas, sulphuric acid steam formed in flue gas is absorbed by fly ash in flue gas, so that sulfuric acid vapor in flue gas is reduced, and about half of sulfur remains in ash when coal is burned. When the oil is burning, the sulfur content in the fuel almost all changes to the ash in the SO2, fuel, the fly ash in the flue gas is very little, and the adsorption ability to the sulphuric acid vapor in the flue gas is very weak.

2. The hydrogen content of oil in the oil-fired boiler is about 11%-12%. The combustion of each ton of fuel oil can produce about 1 ton of water vapor, and the partial pressure of steam in the flue gas is higher than that in the case of coal-burning.

Industrial gas high performance fired 2 ton steam boiler room planning considerations: industrial gas steam boiler room Planning Considerations What? Followed by the degree of technological progress from time to time, the rapid expansion of social economy, people's requirements for industrial gas boiler room planning have become more sophisticated. Now now, in the industrial gas boiler room planning there are still many achievements in urgent need of treatment, therefore, we have to enhance the learning and use of advanced planning practices and advanced technology, from time to time suspend the development and review of industrial gas boiler room planning, the industrial gas boiler housing plan is more suitable, safe, reliable and economical. 2, selection and use of industrial gas boiler at a reasonable selection of urban planning, boiler, environmental management and other mission boiler type is dropped purification, waste power, an important part of reasonable expenses. Set the cost of the boiler is one of the essential elements of when thinking of selection. Because the characteristics of industrial gas boiler itself, the boiler room and equipment to establish a more economical, should be used in high load industrial gas furnace heat boilers in order to reduce the volume of the furnace. Due to the absence of heating surface cleaner, slagging, wear results, the smoke may use a higher speed, reduced scale of the convection heating surface, convection through the rational placement control the industrial gas boiler capacity of coal-fired boiler with a more compact structure, dimensions small, light weight, in order to decrease equipment investment; supporting auxiliary boiler optional satisfactory work. Industrial demand for gas-fired boiler is not equipped with soot blowers, dust, slag and other equipment and fuel dryer slave device, and can save and land acquisition costs placed above equipment; the use of a gas pipeline walks as boiler fuel, not only no fuel storage equipment, supply calm and without prior preparation of fuel processing equipment, greatly simplified the trivial; civil engineering boiler room investment costs and other related costs will lower; no fuel storage, can save shipping costs, place and rest force. Boiler room non-essential equipment such as leak detection equipment for the surge equipment, measurement equipment, gas. Coal, oil, gas boiler three kinds of heat load in the opposite situation, a huge volume of coal-fired boilers, additional slack style drums, Fan, Java machine, dust collector, but also with storage of coal, slag heap place, It covers an area larger. Industrial gas boilers small volume itself, and these need not be equipped with auxiliary equipment, simply set up between a host and auxiliary room, set on more messy, covering economy. Industrial gas boiler city gas source is generally taken from the intermediate pressure gas supply line, the gas pipeline laying gas sampling point to the boiler room, then according to quell's brand, type and caliber regulating device applications, scheduling outlet pressure range, by metering the put into use. Establish a set fee just gas network tariffs, pipeline fees, hot walks pipeline fee. Gas pipeline network overall cost of capital is the sum of the gas company funds charged to the user, it can be determined depending on the circumstances around the gas company. Usually adopted buried gas pipeline type, buried depth is generally about 0.8m ~ 1.0m, seamless steel pipe can be selected or PE pipes, pipe surrounding sand 15cm ~ 20cm plating, hot water pipe laying relatively simple, somewhat messy steam pipe walks . 3, industrial gas boiler room planning results in the presence of 3.1. Selection of the size of the heat load of the boiler and its expansion tend to choose the boiler capacity, the number of great links. The larger heat load, single boiler capacity should be large. The near future can be greatly increased thermal load, it is also relatively large capacity boiler can choose, it will expand the load thought. The only thought to increase the long-term thermal load, the expansion device may leave the boiler placeholder deployment end in the boiler room, or space left on the total FIG. However, in the practice of project planning, often there is a lack of expansion heat load estimates, constitute improper boiler selection, pre-operation to cause unnecessary trouble. 3.2. Gas boiler gas regulator trivial results generally used in high-pressure (less than 5kPa) and medium voltage (5 ~ 150kPa) trivial. Gas usually before entering the boiler room will arrive this requirement. Now the gas hot water boiler is equipped with a high level of automation subsided, a calm requires the gas pressure is lower, so before further demand into a calm pace pressure boiler manufacturers themselves generally equipped. Gas pressure regulating trivial demands reliable equipment, but on the size of the gas pipeline valve is open due to the gas pressure when scheduling the gas pressure is high or low, and tempering will cause off, start and stop frequently subsided's configuration, thereby affecting the boiler work. 3.3. Gas boiler quality results planning standard gauge, the quality can not be ensured when the gas, should be provided or dust, oil and water, respectively, and a total closed drain valve before the gas main pipe before the regulator device. Most of the oil production plant in the use of oil with anger, it is often said of moisture in the summer cold weather, moisture and light hydrocarbons and other substances containing moisture, condensation will constitute a line blockage, an initiative to quell the flame, impact Heating. 3.4. Chimney condensate results because of the high thermal efficiency of industrial gas boiler, a low exhaust gas temperature, typically 180 degrees, the boiler room planning criteria (GB50041-2008) rules industrial gas boiler room chimney should be reinforced concrete or steel chimneys chimney. Chimney will appear directly in the outdoor summer steel chimney condensate freezing results, constitute icing light rusty steel chimney, would constitute a temporary corrosion, freezing severe affect chimney smoke. 3.5. The amount of air to quell the outcome's when quell Industrial gas boiler is in the boiler room, the air between the boiler must be satisfied the requirements apply to quell the device, otherwise there will be no abundant natural gas to quell working carbon monoxide poisoning.

Lu Haiqing chairman welcoming remarks, welcome friends from afar, thanks they have been quick to support each other. As well as in-depth analysis of the current status of environmental demand and domestic gas boiler market, called on everyone to work together to accelerate the popularization and technical upgrading of gas boiler.

High performance gas fired 2 ton steam boiler Related Information

Portable High Efficiency Natural Gas Boiler, Durable

Quality Gas Steam Boiler manufacturers & exporter - buy Portable High Efficiency Natural Gas Boiler, Durable Commercial Steam Boiler from China manufacturer.

Get A Quote

Oil Gas Fuel Fire Tube Packaged Steam Boiler -

Zhongding Boiler adopts the national patent technology, optimizes the design of oil gas boiler, to achieve a more reasonable combustion chamber and heating area, the high thermal efficiency increase more than 10% compare with the ordinary boiler Compare with water tube boiler, this series fire tube boiler has the characteristics of compact structure, small volume, strong load adaptability

Get A Quote

Industrial Steam Boiler on sales - Quality Industrial

Reliable Performance Industrial Steam Boiler Vertical Automatic Wood Fired Steam Boiler Contact Now Reliable performance 200 kg vertical automatic biomass firewood boiler Product Description 1.The furnace adopts three-dimensional three-dimensional circulation air distribution, and has a

Get A Quote

high performance biomass steam boilers in china

costa rica dual fuel fired boiler cost. 2019 Gas Boiler Prices & Costs - Natural Gas, High 2019-8-2 · A typical single-family home can cost anywhere from $1,000 to

Get A Quote

2 ton high pressure gasification gas boiler in spain

Our oil/gas fired boilers can be divided into SZS 2 ton high pressure gasification gas boiler in spain and WNS 2 ton high pressure gasification gas boiler in spain depending on the medium inside the tubes. With multiple pressure designs, the water tube boilers can meet the steam supply requirements of 2

Get A Quote

Alibaba.com

Beijing Double Dragon International Industrial & Mining Machinery Co., Ltd., Experts in Manufacturing and Exporting oil gas fired boiler, coal fired steam boiler and 557 more Products. A Verified CN Gold Supplier on Alibaba.com.

Get A Quote

2 ton oil gas fired boiler parameter and feature, oil

2019-11-28 · The WNS series boiler is horizontal three-pass fire tube gas oil boiler. It is mainly composed by boiler shell, furnace, combustion chamber, flue gas pipes, etc. This paper will give some main technical parameters of 2 ton oil gas fired steam boiler. 2 ton oil gas fired boiler parameter. Boiler model: WNS2-1.25-Y(Q) Rated steam capacity: 2t/h

Get A Quote

onzug steam boiler 27 ton hr - wr-schweisstechnik.de

6 ton coal fired steam boiler with fire tube. 6 ton coal fired steam boiler with fire tube - iloshop.be. 2019-1-21 · 6 ton coal fired steam boiler with fire tube Gas turbine - Wikipedia A gas turbine, also called a combustion turbine, is a type of continuous combustion, internal combustion engine.There are three main .

Get A Quote

Yuanda Boiler - Steam boilerHot water boilerThermal

Henan Yuanda Boiler Co., Ltd. is specialized in the production of oil gas fired steam boiler,coal fired boiler, biomass fired boiler,thermic fluid oil boiler,and industrial hot water boiler and we can customize boiler for you. Welcome to our company for visit and purchase.Tel: +86-18703633064 Addr:Qihang Building D,Hanghai Road,Zhengzhou,China

Get A Quote

China Gas Steam Boiler, Gas Steam Boiler

China Gas Steam Boiler manufacturers - Select 2020 high quality Gas Steam Boiler products in best price from certified Chinese Boiler manufacturers, Oil Boiler suppliers, wholesalers and

Get A Quote

Steam Boiler, Hot water Boiler - Alibaba.com

WNS Fire tube 1000kg 2000kg 3000kg 4000kg 1 ton 2 ton 3 ton 4 ton Natural Gas Fired Steam Boiler Machine for plywood Plant $6,500.00 - $10,000.00 / Set 1 Set (Min. Order)

Get A Quote

1 ton horizontal gas fired boiler - urlaub-in-marina

1 Ton Gas Fired Steam Boiler - steamboilersupplier.com. 2019-3-15 · ZG manufactured 1 ton gas fired steam boilers can greatly improve the boiler's efficiency, save fuel and lower the operation cost so as to arrive at the goal of high performance, energy saving and safety of the boiler.

Get A Quote

1 ton gas steam boiler 2 ton gas steam boiler gas fired

1 Ton Gas Fired Steam Boiler - steamboilersupplier. 2019-3-15 · Overview of 1 Ton Gas Fired Steam Boiler . 1 ton gas fire steam boiler can greatly improve the boilers efficiency, save fuel and lower the operation cost so as to arrive at the goal of high performance, energy saving and safety of the boiler. 1 ton gas fired steam boiler for sale in Gas Boiler Buy And Sale Philippine Boiler

Get A Quote

steam boiler with condenser, high efficiency boiler

2020-5-20 · Main accessories of Gas/Oil fired boiler: Boiler Advantages: 1. High efficiency rating of up to 99% with integrated economizer. 2. Versatile design for using different fuel and multi-fuel fired unit. 3. Satisfy local environment emission level standard strictly. 4. PLC Intelligent Control system, work full-automatically and safety. 5.

Get A Quote

12 Ton Boilers Steam Gas - tabernaelbarracon.com

12 Ton Horizontal Steam Boiler - ferienwohnung . 12 Ton Boilers Steam Gas - apartments-krk-malinska.de. 12 Ton Oil Gas Steam Boiler More Information. 2015/06/14· ZG is a professional industrial steam boiler and hot water boiler factory manufacturer in china,supply 1 ton -20 ton oil and gas fired boiler,the 1 ton,2 ton: 5 : 662Pressure 7- 8 kgs 12 Ton Gas Steam Boiler for Industry- https://'s

Get A Quote

DO YOU HAVE QUESTIONS? WE ARE HERE TO HELP YOU!